AbstractAbout AuthorsReferences
A comprehensive assessment of the process of intensification of grinding of Portland cement clinker is given, as well as an analysis of the strength characteristics of early strength cement is presented. The basic physico-chemical properties and characteristics of modifying additives are considered. The influence of domestic grinding intensifiers on early strength in cement hardening systems has been established. Special attention is paid to the kinetics of the grinding capacity of Portland cement clinker depending on the specific surface of the particles. The greatest attention was paid to the study of the characteristics of samples containing additives of Polyplast LLC. The increase in the early strength of hardening systems containing additives IP-1 and IM-2 of Polyplast LLC is 3.7 MPa. In the proposed formulations, there is also a decrease in the coefficient of water separation.
M.A. GONCHAROVA, Doctor of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.),
L.V. ZAMYSHLYAEVA, Master (This email address is being protected from spambots. You need JavaScript enabled to view it. ),
H.G.H. AL-SURRAYVI, Candidate of Sciences (Engineering)
L.V. ZAMYSHLYAEVA, Master (This email address is being protected from spambots. You need JavaScript enabled to view it. ),
H.G.H. AL-SURRAYVI, Candidate of Sciences (Engineering)
Lipetsk State Technical University (30, Moskovskaya Street, Lipetsk, 398055, Russian Federation)
1. Goncharova M.A., Gorin R.A., Karaseva O.V. The formation of composite curing systems based on technogenic raw materials. Solid State Phenomena. 2018. Vol. 284, pp. 1058–1062. https://doi.org/10.4028/www.scientific.net/SSP.284.1058
2. Goncharova M.A., Korneev K.A., Dedyaev G.S. Improving construction engineering properties of soils stabilized by a cement binder with techno-genic products. Solid State Phenomena. 2020. Vol. 299, pp. 26–31. DOI: 10.4028/www.scientific.net/SSP.299.26
3. Федюк Р.С., Мочалов А.В., Лесовик В.С. Современные способы активации вяжущего и бетонных смесей (обзор) // Вестник Инженерной школы Дальневосточного федерального университета. 2018. № 4 (37). С. 85–99. DOI: 10.5281/zenodo.2008670
3. Fedyuk R.S., Mochalov A.V., Lesovik V.S. Modern methods of activation of binder and concrete mixtures (review). Vestnik Inzhenernoi shkoly DVFU, FEFU: School of Engineering Bulletin. 2018. No. 4 (37), pp. 85–99. (In Russian). DOI: 10.5281/zenodo.2008670
4. Аль-Суррайви Х.Г.Х., Гончарова М.А., Заева А.Г. Синтез композитов на основе местного сырья при воздействии агрессивной среды // Строительные материалы. 2021. № 5. С. 69–74. DOI: https://doi.org/10.31659/0585-430X-2021-791-5-69-74
4. Al-Surraivi H.G.H., Goncharova M.A., Zaeva A.G. Synthesis of composites based on local raw materials under the influence of an aggressive environment. Stroitel’nye Materialy [Construction Materials]. 2021. No. 5, pp. 69–74. (In Russian). DOI: 10.31659/0585-430X-2021-791-5-69-74
5. Zawal D., Grabiec A. M. Influence of selected mineral additives on properties of recycled aggregate concrete (RAC) considering eco-efficiency coefficients. Case Studies in Construction Materials. 2022. Vol. 17. e01405. https://doi.org/10.1016/j.cscm.2022.e01405
6. Prajna S.P., Anjum M.I., Lakshmi P.S., Gayathri G., Beulah M., Sudhir M.R. A comprehensive investigation of the effect of mineral additives to bituminous concrete. Materials Today: Proceedings. 2021. Vol. 46, pp. 714–721. https://doi.org/10.1016/j.matpr.2020.12.090.
7. Рахимов Р.З. Строительный комплекс. Экология и минеральные вяжущие вещества // Известия высших учебных заведений. Строительство. 2022. № 2 (758). С. 5–15. DOI: 10.32683/0536-1052-2022-758-2-5-15
7. Rakhimov R.Z. Building complex, Ecology and mineral binders. Izvestiya vysshikh uchebnykh zavedenii. Stroitel’stvo. 2022. No. 2 (758), pp. 5–15. (In Russian). DOI: 10.32683/0536-1052-2022-758-2-5-15
8. Golewski G.L. An extensive investigations on fracture parameters of concretes based on quaternary binders (QBC) by means of the DIC technique. Construction and Building Materials. 2022. Vol. 351. 128823. https://doi.org/10.1016/j.conbuildmat.2022.128823
9. Смирнова О.М., Казанская Л.Ф. Гибридные цементы на основе гранулированных доменных шлаков: основные направления исследований // Эксперт: теория и практика. 2022. № 3 (18). С. 59–65. DOI: 10.51608/26867818_2022_3_59
9. Smirnova O.M., Kazanskaya L.F. Hybrid cements based on granulated blast furnace slag: the main directions of research. Expert: theoriya i practika. 2022. No. 3 (18), pp. 59–65. (In Russian). DOI: 10.51608/26867818_2022_3_59
10. Russo F., Eskandarsefat S., Venturini L., Viscione N. A complete study on an asphalt concrete modified with graphene and recycled hard-plastics: A case study. Case Studies in Construction Materials. 2022.
2. Goncharova M.A., Korneev K.A., Dedyaev G.S. Improving construction engineering properties of soils stabilized by a cement binder with techno-genic products. Solid State Phenomena. 2020. Vol. 299, pp. 26–31. DOI: 10.4028/www.scientific.net/SSP.299.26
3. Федюк Р.С., Мочалов А.В., Лесовик В.С. Современные способы активации вяжущего и бетонных смесей (обзор) // Вестник Инженерной школы Дальневосточного федерального университета. 2018. № 4 (37). С. 85–99. DOI: 10.5281/zenodo.2008670
3. Fedyuk R.S., Mochalov A.V., Lesovik V.S. Modern methods of activation of binder and concrete mixtures (review). Vestnik Inzhenernoi shkoly DVFU, FEFU: School of Engineering Bulletin. 2018. No. 4 (37), pp. 85–99. (In Russian). DOI: 10.5281/zenodo.2008670
4. Аль-Суррайви Х.Г.Х., Гончарова М.А., Заева А.Г. Синтез композитов на основе местного сырья при воздействии агрессивной среды // Строительные материалы. 2021. № 5. С. 69–74. DOI: https://doi.org/10.31659/0585-430X-2021-791-5-69-74
4. Al-Surraivi H.G.H., Goncharova M.A., Zaeva A.G. Synthesis of composites based on local raw materials under the influence of an aggressive environment. Stroitel’nye Materialy [Construction Materials]. 2021. No. 5, pp. 69–74. (In Russian). DOI: 10.31659/0585-430X-2021-791-5-69-74
5. Zawal D., Grabiec A. M. Influence of selected mineral additives on properties of recycled aggregate concrete (RAC) considering eco-efficiency coefficients. Case Studies in Construction Materials. 2022. Vol. 17. e01405. https://doi.org/10.1016/j.cscm.2022.e01405
6. Prajna S.P., Anjum M.I., Lakshmi P.S., Gayathri G., Beulah M., Sudhir M.R. A comprehensive investigation of the effect of mineral additives to bituminous concrete. Materials Today: Proceedings. 2021. Vol. 46, pp. 714–721. https://doi.org/10.1016/j.matpr.2020.12.090.
7. Рахимов Р.З. Строительный комплекс. Экология и минеральные вяжущие вещества // Известия высших учебных заведений. Строительство. 2022. № 2 (758). С. 5–15. DOI: 10.32683/0536-1052-2022-758-2-5-15
7. Rakhimov R.Z. Building complex, Ecology and mineral binders. Izvestiya vysshikh uchebnykh zavedenii. Stroitel’stvo. 2022. No. 2 (758), pp. 5–15. (In Russian). DOI: 10.32683/0536-1052-2022-758-2-5-15
8. Golewski G.L. An extensive investigations on fracture parameters of concretes based on quaternary binders (QBC) by means of the DIC technique. Construction and Building Materials. 2022. Vol. 351. 128823. https://doi.org/10.1016/j.conbuildmat.2022.128823
9. Смирнова О.М., Казанская Л.Ф. Гибридные цементы на основе гранулированных доменных шлаков: основные направления исследований // Эксперт: теория и практика. 2022. № 3 (18). С. 59–65. DOI: 10.51608/26867818_2022_3_59
9. Smirnova O.M., Kazanskaya L.F. Hybrid cements based on granulated blast furnace slag: the main directions of research. Expert: theoriya i practika. 2022. No. 3 (18), pp. 59–65. (In Russian). DOI: 10.51608/26867818_2022_3_59
10. Russo F., Eskandarsefat S., Venturini L., Viscione N. A complete study on an asphalt concrete modified with graphene and recycled hard-plastics: A case study. Case Studies in Construction Materials. 2022.
For citation: Goncharova M.A., Zamyshlyaeva L.V., Al-Surrayvi H.G.H. Modification of cement hardening systems by using energy-efficient technological additives of domestic production. Stroitel’nye Materialy [Construction Materials]. 2023. No. 1–2, pp. 50–54. (In Russian). DOI: https://doi.org/10.31659/0585-430X-2023-810-1-2-50-54