Resistance of Binding Systems of Various Compositions to the Action of Molds

Number of journal: 11-2020
Autors:

Strokova V.V.,
Nelubova V.V.,
Sivalneva M.N.,
Rykunova M.D.,
Shapovalov N.A.

DOI: https://doi.org/10.31659/0585-430X-2020-786-11-41-46
УДК: 630*381.2: 677.019.382

 

AbstractAbout AuthorsReferences
The dynamic development of urbanization contributes to an increase in emissions of industrial waste, which is the cause dysfunction of the ecosystem balance and leads to the development of biological corrosion on building materials associated with the products of the vital activity of microorganisms. In this regard, it is necessary to assess the resistance of composites to predict the durability of building structures under conditions of biological influence of microorganisms. Binder systems of various compositions were studied: cementless nanostructured binders (NB) based on quartz sand and granodiorite, gypsum, Portland cement and alumina cement. The toxicity of binders was assessed by biotesting on living organisms – cladocerans Daphnia Magna – according to the criteria of the intensity of their growth and viability. As a result, the high environmental safety of NB is substantiated, and the ranking of the studied binders according to the degree of increase in their toxicity to test objects is presented. Fungal resistance was assessed by the ability of molds for growing and reproduction on the studied samples. It was found that the most active in terms of the development of binders were representatives of the genus Aspergillus, the intensity of growing of which in all variants did not decrease below 3 points. Gypsum and NB were especially vulnerable, where the degree of fouling repeatedly reached 5 points. Even the initially biostable cement, after the aging process, lost its stability at different extent. The obtained results indicate the need to increase the resistance of composites for various purposes under conditions of biocorrosion at the stage of design and updating of regulatory documents, including tests for fungal resistance in the list of mandatory.
V.V. STROKOVA, Doctor of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.),
V.V. NELUBOVA, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.),
M.N. SIVALNEVA, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.),
M.D. RYKUNOVA, Engineer (graduate student) (This email address is being protected from spambots. You need JavaScript enabled to view it.),
N.A. SHAPOVALOV, Doctor of Sciences (Engineering)

Belgorod State Technological University named after V.G. Shukhov (46, Kostyukova Street, Belgorod, 308012, Russian Federation)

1. Erofeev V.T., Rodin A.I., Suraeva E.N., Bogatov A.D., Kaznacheev S.V. Biocidal portland cement. Stroi-tel’stvo i rekonstruktsiya. 2016. No. 1 (63), pp. 83–90. (In Russian).
2. Suraeva E.N., Erofeev V.T., Korolev E.V. Investigation of bioresistant dry building mixes modified by carbon nanotubes. Vestnik MGSU. 2015. No. 4, pp. 104–114. (In Russian).
3. Erofeev V.T., Kaznacheev S.V., Bogatov A.D., Spirin V.A., Svetlov D.A., Bogatova S.N. Research of the concrete composites resistance modified by guanidine based biocidal preparations in the model environment of filamentous fungi. Internet-Vestnik VolgGASU. 2012. Iss. 1 (20), pp. 31. (In Russian).
4. Stroganov V.F., Sagadeev E.V. Biodamage building materials. Stroitel’nye Materialy [Construction Materials]. 2015. No. 5, pp. 5–9. (In Russian).
5. Stroganov V.F., Sagadeev E.V., Boichuk V.A., Stoyanov O.V., Moukhametova A.M. Polymer protective coatings against biocorrosion. Vestnik Kazanskogo tekhnologicheskogo universiteta. 2014. Vol. 17. No. 18, pp. 149–154. (In Russian).
6. Zalepkina S.А., Smirnov V.F., Borisov А.V., Matsulevich Z.V., Smirnova О.N., Artemeva M.M. Bactericidal and fungicidal activities of Se(S), N-containing heterocyclic compounds and their influence on growth rate of micromycete – industrial material decomposers. Fundamental’nye issledovaniya. 2015. No. 10, pp. 25–30. (In Russian).
7. Kozhukhova N.I., Zhernovskii I.V., Strokova V.V. Assessment of the bio-positivity of geopolymer binders based on low-calcium fly ash. Stroitel’nye Materialy [Construction Materials]. 2012. No. 9, pp. 84–85. (In Russian).
8. Grishina A.N., Korolev E.V. Chemical composition of silica-based biocidal modifier. Vestnik MGSU. 2016. No. 11, pp. 58–67. DOI: 10.22227/1997-0935.2016.11.59-67 (In Russian).
9. Grishina A.N., Korolev E.V. Strength of gypsum stone containing biocidal modifier. Evraziiskii Soyuz Uchenykh (ESU). 2016. No. 30, pp. 21–24. (In Russian).
10. Sivalneva M.N., Nelubova V.V., Kobzev V.A. Evolution of zero-cement nanostructured binders of different topogenetic belonging. Stroitel’stvo i tekhnogennaya bezopasnost’. 2019. No. 14 (66), pp. 73–83. (In Russian).
11. Zhernovskii I.V., Osadchaya M.S., Cherevatova A.V., Strokova V.V. Aluminosilicate nanostructured binder based on granite raw materials. Stroitel’nye Materialy [Construction Materials]. 2014. No. 1–2, pp. 38–41. (In Russian).
12. Cherevatova A.V., Zhernovskaya I.V., Alehin D.A., Kozhukhova M.I., Kozhukhova N.I., Yakovlev E.A. Theoretical aspects of development of composite nanostructured gypsum binder characterized by increased heat resistance. Stroitel’nye materialy i izdeliya. 2019. Vol. 2. No. 4, pp. 5–13. (In Russian).
13. Kobzev V.A., Sivalneva M.N., Nelubova V.V. highly-concentrated aluminosilicate binder suspension from granodiorite. Vestnik BGTU im. V.G. Shukhova. 2018. No. 1, pp. 12–18. DOI: 10.12737/article_5a5dbd2cae9c28.43666650 (In Russian).
14. Strokova V.V., Nelubova V.V., Sivalneva M.N., Kobzev V.A. Phytotoxicity analysis of different compositions of nanostructured binder. Key Engineering Materials. 2017. Vol. 761, pp. 189. DOI: 10.4028/www.scientific.net/KEM.761.189
15. Strokova V.V., Nelyubova V.V., Rykunova M.D., Danakin D.N. Toxicity of binders as an element of the urban ecosystems. Stroitel’stvo i tekhnogennaya bezopasnost’. 2018. No. 12 (64), рр. 167–178. (In Russian).
16. Strokova V.V., Goncharova E.N., Nelubova V.V., Rykunova M.D. Biocoenosis of construction objects of live stockbreeding complexes with due account for industrial profile. Advances in Engineering Research. 2018. Vol. 151, pp. 601–605. DOI: https://doi.org/10.2991/agrosmart-18.2018.112.

For citation: Strokova V.V., Nelubova V.V., Sivalneva M.N., Rykunova M.D., Shapovalov N.A. Resistance of binding systems of various compositions to the action of molds. Stroitel’nye Materialy [Construction Materials]. 2020. No. 11, pp. 41–46. (In Russian). DOI: https://doi.org/10.31659/0585-430X-2020-786-11-41-46


Print   Email