The Study of the Influence of Graphene Oxide on the Strength of Cement Stone Using River Sand

Number of journal: №1-2-2019
Autors:

Fedorova G.D.
Skriabin A.P.
Aleksandrov G.N.

DOI: https://doi.org/10.31659/0585-430X-2019-767-1-2-16-22
УДК: 691.545:539.2

 

AbstractAbout AuthorsReferences
A review of foreign literature on the study of graphene oxide as an additive for cement composites is presented. It is shown that every year the volume of research in this area increases significantly, and the results indicate the prospects of its use as a modifier of cement stone and solidified solution. The results of the study of the influence of graphene oxide in an amount of 0.05% by weight of cement on the strength of cement stone using river sand belonging to a group of very small are presented. It is established that graphene oxide significantly increases the strength at an early stage of hardening when bending (by 22.4%) than when compressing (by 9.1%). At 28 days of age, the increase in strength when bending and when compressing was only 2.2% and 4.6%, respectively. A possible reason for a slight increase in the strength of the cement stone is the quality of the graphene oxide suspension. Thus, the necessity of modification of graphene oxide suspension to control the structure formation of the cement stone microstructure is revealed.
G.D. FEDOROVA, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.)
A.P. SCRYABIN, Undergraduate
G.N. ALEXANDROV, Master

North-Eastern Federal University in Yakutsk (58, Belinskogo Street, Yakutsk, 677000, Russian Federation)

1. Ву Х.Ч. Неорганические вяжущие: новый взгляд на процесс гидратации и твердения // «ALITinform» Международное аналитическое обозрение. Цемент. Бетон. Сухие смеси. 2014. № 1 (33). С. 26–43.
1. Wu H.C. Inorganic cements: review and reexamination. «ALITinform» International Analitical Review. Cement. Concrete. Dry Mixtures. 2014. No. 1 (33), pp. 26–43. (In Russian).
2. Карпова E.А., Мохамед Али Элсаед, Скрипкюнас Г., Керене Я., Кичайте А., Яковлев Г.И., Мацияускас М., Пудов И.А., Алиев Э.В., Сеньков С.А. Модификация цементного бетона комплексными добавками на основе эфиров поликарбоксилата, углеродных нанотрубок и микрокремнезема // Строительные материалы. 2015. № 2. С. 40–47.
2. Karpova E.A., Mohamed Ali Elsaed, Skripkiunas G., Keriene Ja., Kiaite A., Yakovlev G.I., Macijauskas M., Pudov I.A., Aliev E.V., Sen’kov S.A. Modification of сement сoncrete by use of сomplex additives based on the polycarboxylate ether, carbon nanotubes and microsilica. Stroitel’nye Materialy [Construction Materials]. 2015. No. 2, pp. 40–47. (In Russian).
3. Лхасаранов С.А., Урханова Л.А., Буяннтуев С.Л. Исследование фазового состава цементного камня с углеродными наноматериалами // Строительные материалы. 2018. № 1–2. С. 23–25.
3. Fedorova G.D., Alexandrov G.N., Scryabin A.P., Baishev K.F. Influence of graphene oxide on compressive strength of cement paste. Stroitel’nye Materialy [Construction Materials]. 2018. No. 1–2, pp. 11–17. DOI: https://doi.org/10.31659/0585-430X-2018-756-1-2-11-17 (In Russian).
4. Пухаренко Ю.В., Староверов В.Д., Рыжов Д.И. Фуллероидные углеродные наночастицы для модификации бетонов // Технологии бетонов. 2015. № 3–4. С. 40–43.
4. Pucharenko Yu.V., Staroverov V.D., Ryzhev V.D. Staroverov D.I. Fulleroid carbon nanoparticles for modifying concrete. Technologii betonov. 2015. No. 3–4, pp. 40–43. (In Russian).
5. Wang Q., Wang J., Lu C-X. and etc. Influence of graphene oxide additions on the microstructure and mechanical strength of cement. New Carbon Materials. 2015. Vol. 30. Iss. 4, pp. 349–359.
6. Pan Z., He L., Qiu L., Korayem A.H. and etc. Mechanical properties and microstructure of a grapheme oxide – cement composite. Cement & Concrete Composites. 2015. Vol. 58, pp. 140–147.
7. Fakhim B., Hassani A., Rashidi A., Ghodousi P. Preparation and mechanical proprieties of graphene oxide: cement nanocomposites. The Scientific World Journal. 2014. Vol. 20, pp. 1–10.
8. Yang H., Monasterio M., Cui H., Han N. Experimental study of the effects of graphene oxide on microstructure and properties of cement paste composite. Composites Part A: Applied Science and Manufacturing. 2017. Vol. 102, pp. 263–272.
9. Xiangyu Li, Zeyu Lu, Samuel Chuah and etc. Effect of grapheme oxide aggregates on hydration degree, sorptivity, and tehsile splitting strength of cement paste. Composites Part A: Applied Science and Manufacturing. 2017. Vol. 100, pp. 1–8.
10. Федорова Г.Д., Баишев К.Ф., Скрябин А.П. Оксид графена как перспективный материал для цементных композитов // Научное обозрение. 2017. № 12. С. 36–41.
10. Fedorova G.D., Baishev K.F., Skryabin A.P. Graphene oxide as a promising nanomaterial for cement. Nauchnoe obozrenie. 2017. No. 12, pp. 36–41. (In Russian).
11. Федорова Г.Д., Александров Г.Н., Скрябин А.П., Баишев К.Ф. Влияние оксида графена на прочность при сжатии цементного камня // Строительные материалы. 2018. № 1–2. С. 11–17.
11. Fedorova G.D., Alexandrov G.N., Scryabin A.P., Baishev K.F. Influence of graphene oxide on compressive strength of cement paste. Stroitel’nye Materialy [Construction Materials]. 2018. No. 1–2, pp. 11–17. DOI: https://doi.org/10.31659/0585-430X-2018-756-1-2-11-17. (In Russian).
12. Kapitonov A.N. et al. Characterization of graphene oxide suspension for fluorescence quenching in DNA-diagnostics. Korean Journal of Materials Research. 2016. Vol. 26. No. 1, pp. 1–7.
13. Peng Hui, Ge Yaping, Cai C.S. and etc. Mechanical properties and microstructure of grapheme oxide cement-based composites. Construction and Building Materials. 2019. Vol. 194, pp. 102–109. https://doi.org/10.1016/j.conbuildmat.2018.10.234
14. Wu-Jian Long, Jing-Jie Wei, Feng Xing and etc. Enhanced dynamic mechanical properties of cement paste modified with graphene oxide nanosheets and its reinforcing mechanism. Cement and Concrete Composites. 2018. Vol. 93, pp. 127–139. https://doi.org/10.1016/j.cemconcomp.2018.07.001
15. Zhao Li, Guo Xinli, Liu Yuanyuan, Zhao Yuhong and etc. Hydration kinetics, pore structure, 3D network calcium silicate hydrate, and mechanical behavior of graphene oxide reinforced cement composites. Construction and Building Materials. 2018. Vol. 190, pp.150–163. https://doi.org/10.1016/j.conbuildmat.2018.09.105

For citation: Fedorova G.D., Skriabin A.P., Aleksandrov G.N. The study of the influence of graphene oxide on the strength of cement stone using river sand. Stroitel’nye Materialy [Construction Materials]. 2019. No. 1–2, pp. 16–22. DOI: https://doi.org/10.31659/0585-430X-2019-767-1-2-16-22 (In Russian).


Print   Email