Composite Polymer Mesh for Stone Masonry

Number of journal: 9-2019
Autors:

Stepanova V.F.
Buchkin A.V.
Yurin E.Yu.
Nikishov E.I.
Ishchuk М.К.
Granovsky A.V.
Dzhamuev B.K.
Aizyatullin Kh.A.

DOI: https://doi.org/10.31659/0585-430X-2019-774-9-44-50
УДК: 693.25

 

AbstractAbout AuthorsReferences
With development and introduction of technologies of production of composite materials of construction appointment, in Russia there were composite flexible connections, anchors, fittings, etc. These materials and products are not fundamentally new, and previously studied for the purpose of using for reinforcement of concrete or structural elements, but for increasing the bearing capacity of stone structures as masonry meshes are practically not used, while the stone masonry mesh is one of the most popular materials in construction. Experimental studies of composite meshes of different types and technology of execution used in the stone masonry are presented. An experimental evaluation of the effectiveness of composite meshes in the stone masonry was carried out, the values of crack-forming and destructive loads were determined, the features of the stress-strain state of composite meshes as flexible connections were revealed, the fields of application were formulated.
V.F. STEPANOVA1, Doctor of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.)
A.V. BUCHKIN1, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.)
E.YU. YURIN1, Scientific worker, (This email address is being protected from spambots. You need JavaScript enabled to view it.)
E.I. NIKISHOV1, Engineer, (This email address is being protected from spambots. You need JavaScript enabled to view it.)
М.К. ISHCHUK2, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.)
A.V. GRANOVSKY2, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.)
B.K. DZHAMUEV2, Candidate of Sciences (Engineering) (This email address is being protected from spambots. You need JavaScript enabled to view it.)
KH.A. AIZYATULLIN2, Master (This email address is being protected from spambots. You need JavaScript enabled to view it.)

1 Research Institute of Concrete and Reinforced Concrete named after A.A. Gvozdev (NIIZHB) JSC “Research Center of Construction” (6, 2-nd Institutskaya Street, Moscow 109428, Russian Federation)
2 Research Institute of Building Constructions named after V.A. Koucherenko (TSNIISK) JSC Research Center of Construction (6, 2-nd Institutskaya Street, Moscow 109428, Russian Federation)

1. Stepanova V.F., Stepanov A.Yu., Zhirkov E.P. Armatura kompozitnaya polimernaya [Composite polymer reinforcement]. Moscow: ASV. 2013. 200 p.
2. Buchkin A.V., Shevnin A.A., Semenova S.V. The main directions of development of the regulatory framework for composite materials in construction. Actual issues of the theory and practice of using composite reinforcement in construction. Collection of materials of the fourth scientific and technical conference. Izhevsk. 2018, pp. 8–15. (In Russian).
3. SP (Set of rules) 15.13330.2012. Stone and armored constructions. SNiP II-22–81*. Ministry of Regional Development of Russia. Moscow. 2012. 78 p. (In Russian).
4. SP (Set of rules) 327.1325800.2017. Exterior walls with a front brick layer. Rules for the design, operation and repair. Moscow. 2017. 33 p. (In Russian).
5. Ishchuk M.K., Shiray M.V. Strength and deformation of large-size ceramic stone masonry with filling of voids with heat insulation. Stroitel’nye Materialy [Construction Materials]. 2012. No. 5, pp. 93–95. (In Russian).
6. Ishchuk M.K., Gogua O.K., Alekhin D.A., Fayzov D.Sh., Frolova I.G., Nikolaev V.V. Experimental studies of the strength and deformation of anchoring basalt-plastic ties to break out of masonry mortars before and after fire exposure. Promyshlennoye i grazhdanskoye stroitel’stvo. 2016. No. 12, pp. 49–52. (In Russian).
7. Ishchuk M.K., Gogua O.K., Alekhin D.A., Fayzov D.Sh., Nikolaev V.N., Litvinov E.A., Popov A.A. Fire resistance of non-bearing external walls with face layer of brick masonry with flexible basalt-plastic bracings. Zhilishchnoe Stroitel’stvo [Housing Construction]. 2016. No. 11, pp. 35–37. (In Russian).
8. Ishchuk M.K., Gogua O.K., Frolova I.G. Features of operation of flexible ties in the walls with the facing layer of stone masonry. Stroitel’nye Materialy [Construction Materials]. 2018. No. 7, pp. 40–44. DOI: 10.31659/0585-430X-2018-761-7-40-44 (In Russian).
9. Sokolov B.S., Antakov A.B. Issledovaniya szhatykh elementov kamennykh i armokamennykh konstruktsiy [Studies of compressed elements of stone and reinforced stone structures]. Moscow: ASV. 2010. 111 p.
10. Sokolov B.S., Antakov A.B. Prochnost’, zhestkost’ i treshchinostoykost’ szhatykh kamennykh i armokamennykh kladok [Strength, stiffness and crack resistance of compressed masonry and reinforced masonry]. Kazan: Center for Innovative Technologies. 2018. 169 p.
11. Antakov A.B. Antakov A.B. Strength of masonry reinforced with composite nets. Uspekhi sovremennogo yestestvoznaniya. 2014. No. 7, pp. 116–120. (In Russian).
12. Antakov A.B., Plotnikov A.N., Pozdeev V.M. Bearing capacity of masonry reinforced with basalt-plastic reinforcement nets. Collection of reports of the International Scientific Conference dedicated to the 85th anniversary of the Department of reinforced concrete and stone structures and the 100th anniversary of the birth of N.N. Popova / Ed. by Tamrazyana A.G., Kopanitsa D.G. Moscow. April 19–20, 2016, pp. 15–21. (In Russian).

For citation: Stepanova V.F., Buchkin A.V., Yurin E.Yu., Nikishov E.I., Ishchuk М.К., Granovsky A.V., Dzhamuev B.K., Aizyatullin Kh.A. Composite polymer mesh for stone masonry. Stroitel’nye Materialy [Construction Materials]. 2019. No. 9, pp. 44–50. (In Russian). DOI: https://doi.org/10.31659/0585-430X-2019-774-9-44-50


Print   Email