AbstractAbout AuthorsReferences
Physical and mechanical properties of a bitumen-mineral mixture (strength, water saturation, compaction factor) are established for patching repair of road pavements of a non-rigid type with the use of jet-injection method. On the basis of obtained results of the laboratory studies with the use of a full factorial analysis, an analytical dependence of influence of tech- nological modes of stacking of the mixture when laying it in a pothole under different technological regimes and different volume of the mixture in the percent for the content of bitumen emulsion has been established. It is shown that the obtained value of water saturation of the material corresponds to the normative values of GOST 9128–2009 only with 10%-content of the emulsion by volume and an average feed rate of 30 m/s. It is proven that for increasing the service life of the repaired surface of road pavements, there is a need for additional compaction of the mixture in the pothole with tamping machines
M.E. PILECKIJ, Engineer,
I.V. DIDRIKH, Candidate of Sciences (Engineering),
A.F. ZUBKOV, Doctor of Sciences (Engineering),
К.A. АNDRIANOV, Candidate of Sciences (Engineering)
I.V. DIDRIKH, Candidate of Sciences (Engineering),
A.F. ZUBKOV, Doctor of Sciences (Engineering),
К.A. АNDRIANOV, Candidate of Sciences (Engineering)
Tambov State Technical University (112, bldg.E, Michurinskaya Street, Tambov, 392032, Russian Federation)
1. Apestin, V.K. On the discrepancy between the design and regulatory life of road clothes. Nauka i tekhnika v dorozhnoj otrasli. 2011. No. 1, pp. 18–20. (In Russian).
2. Adler Yu.P., Markova E.V., Granovskiy Yu.V. Planirovanie ehksperimenta pri poiske optimal’nyh uslovij [Planning an experiment when searching for optimal conditions]. Moscow: Nauka. 1971. 282 p.
3. Kasatkin A.G. Osnovnye processy i apparaty himicheskih tekhnologij [The main processes and apparatus of chemical technology. 7-th ed]. Moscow: The State Scientific and Technical Publishing House of Chemical Literature. 1961. 830 p.
4. Ermakov S.M. Matematicheskaya teoriya planirovaniya ehksperimenta [Mathematical theory of experiment planning]. Moscow: Nauka. 1983. 392 p.
5. Piletskiy M.E., Zubkov A.F. Analysis of the condition of the roads of the Tambov region and the choice of technology for repairing potholes on non-rigid type coatings. Nauchnyi vestnik Voronezhskogo GASU. Stroitel’stvo i arkhitektura. 2016. Vol. 1 (41), pp. 73–82. (In Russian).
6. Piletsky M.E., Nekrasov D.A., Chaplygin I.S. The results of experimental studies of the laying of mixtures in the jet-injection method. Sustainable development of the region: architecture, construction, transport: materials of the 3rd international scientific-practical conference of the Institute of ArkhSiT. Tambov. 2016, pp. 171–176. (In Russian).
7. Giyasov B.I., Kupriyanov R.V., Andrianov K.A., Zubkov A.F. Calculation of the temperature of asphalt concrete in the construction of joints of multilane road pavements of non-rigid type. Vestnik MGSU. 2015. No. 3, pp. 17–29. (In Russian).
8. Piletskiy M.E., Zubkov A.F. Comparative evaluation of the effectiveness of the methods of patching of road pavements of non-rigid type. Transport systems of Siberia. Development of the transport system as a catalyst for the growth of the state economy. International scientific-practical conference. 2016, pp. 208–211. (In Russian).
9. Kupriyanov R.V., Luzgachev V.A., Zubkov A.F. Determination of the temperature of the asphalt-concrete mixture in the construction of road pavements of non-rigid type. Nauchnyi vestnik Voronezhskogo GASU. Stroitel’stvo i arkhitektura. 2015. № 3 (39) 2015, pp. 68–77. (In Russian).
10. Munir D. Nazzal, Sang-Soo Kim P.E. Evaluation of Winter Pothole Patching Methods Report. Final Report. The Ohio Department of Transportation. Office of Statewide Planning & Research State Job. № 134724. January 2014, pp. 13–17.
11. Griffith A. Improved Winter Pothole Patching. State Planning And Research Project Number 538. Oregon Department of Transportation Research. August 1998. h t t p : / / c i m l i n e p m g . c o m / f i l e s / e d u c a t i o n / OregonPotholePatchingStudy.pdf (date of access 21.05.2017).
12. Research Report: Spray Injection Pothole Patching. The Road Ahead. Virginia: Virginia Transportation Technology Transfer Center. 2003, pp. 1–6
2. Adler Yu.P., Markova E.V., Granovskiy Yu.V. Planirovanie ehksperimenta pri poiske optimal’nyh uslovij [Planning an experiment when searching for optimal conditions]. Moscow: Nauka. 1971. 282 p.
3. Kasatkin A.G. Osnovnye processy i apparaty himicheskih tekhnologij [The main processes and apparatus of chemical technology. 7-th ed]. Moscow: The State Scientific and Technical Publishing House of Chemical Literature. 1961. 830 p.
4. Ermakov S.M. Matematicheskaya teoriya planirovaniya ehksperimenta [Mathematical theory of experiment planning]. Moscow: Nauka. 1983. 392 p.
5. Piletskiy M.E., Zubkov A.F. Analysis of the condition of the roads of the Tambov region and the choice of technology for repairing potholes on non-rigid type coatings. Nauchnyi vestnik Voronezhskogo GASU. Stroitel’stvo i arkhitektura. 2016. Vol. 1 (41), pp. 73–82. (In Russian).
6. Piletsky M.E., Nekrasov D.A., Chaplygin I.S. The results of experimental studies of the laying of mixtures in the jet-injection method. Sustainable development of the region: architecture, construction, transport: materials of the 3rd international scientific-practical conference of the Institute of ArkhSiT. Tambov. 2016, pp. 171–176. (In Russian).
7. Giyasov B.I., Kupriyanov R.V., Andrianov K.A., Zubkov A.F. Calculation of the temperature of asphalt concrete in the construction of joints of multilane road pavements of non-rigid type. Vestnik MGSU. 2015. No. 3, pp. 17–29. (In Russian).
8. Piletskiy M.E., Zubkov A.F. Comparative evaluation of the effectiveness of the methods of patching of road pavements of non-rigid type. Transport systems of Siberia. Development of the transport system as a catalyst for the growth of the state economy. International scientific-practical conference. 2016, pp. 208–211. (In Russian).
9. Kupriyanov R.V., Luzgachev V.A., Zubkov A.F. Determination of the temperature of the asphalt-concrete mixture in the construction of road pavements of non-rigid type. Nauchnyi vestnik Voronezhskogo GASU. Stroitel’stvo i arkhitektura. 2015. № 3 (39) 2015, pp. 68–77. (In Russian).
10. Munir D. Nazzal, Sang-Soo Kim P.E. Evaluation of Winter Pothole Patching Methods Report. Final Report. The Ohio Department of Transportation. Office of Statewide Planning & Research State Job. № 134724. January 2014, pp. 13–17.
11. Griffith A. Improved Winter Pothole Patching. State Planning And Research Project Number 538. Oregon Department of Transportation Research. August 1998. h t t p : / / c i m l i n e p m g . c o m / f i l e s / e d u c a t i o n / OregonPotholePatchingStudy.pdf (date of access 21.05.2017).
12. Research Report: Spray Injection Pothole Patching. The Road Ahead. Virginia: Virginia Transportation Technology Transfer Center. 2003, pp. 1–6
For citation: Pileckij M.E., Didrikh I.V., Zubkov A.F., Аndrianov К.A. Research of bitumen-mineral mixture applied for patching repair of road pavements using jet-injection method. Stroitel’nye Materialy [Construction Materials]. 2017. No. 6, pp. 19–23. DOI: https://doi.org/10.31659/0585-430X-2017-749-6-19-23. (In Russian).